CONTACT US

Our Address

Science Avenue, High-tech Zone, Zhengzhou City, Henan Province, China

  • The interaction of grinding media and collector in

    Author: Yufan Mu, Yupu Cheng, Yongjun Peng
  • Influence of grinding media, pyrite mineralogy and

    2020-4-10  (2019). Influence of grinding media, pyrite mineralogy and water chemistry on the galvanic interaction between grinding media and pyrite. Canadian Metallurgical Quarterly: Vol. 58,

  • The interaction between grinding media and collector

    Cited by: 2
  • The interaction of grinding media and collector in

    Author: Yufan Mu, Yupu Cheng, Yongjun Peng
  • Effect of grinding media on the activation of pyrite

    The effect of grinding media on the flotation of pyrite activated by Cu(2+) or Pb(2+) is through the change of pulp potential and iron oxidation species emanating from the media. The iron oxidation species from grinding media is electrostatically repulsive with respect to copper-activated pyrite and therefore, reducing conditions produced by ...

  • Review of the effect of grinding media on flotation of ...

    No clear trend has been revealed by testwork into the effects of grinding media on pyrite flotation. Many workers have found that pyrite tends to float faster in the presence of collectors following mild steel grinding (Table 4). Learmont and Iwasaki [41], Martin [28], Bruce [3]

  • Effect of Pyrite and Pyrrhotite on the Corrosive Wear

    2020-7-1  However, the rest potential of pyrite was unstable and drifted toward nobler direction over time. The curve, labeled Py (porcelain), shows an example after 15 min. of equilibration. This passivation-like behavior became evident under anodic polarization. During grinding, abraded steel-debris are generated by the abrasive wear of grinding media.

  • Galvanic interaction of grinding media with pyrite and

    Nomenclature α Py/MS. surface area ratio of pyrite to mild steel. α. surface area rate of pyrite contacting with mild steel. A MS and A Py. surface area of mild steel and pyrite respectively, cm 2. A Py (t). surface area of pyrite and a function of the grinding time, cm 2 [C aq]concentration of the metal ion or sulphur analysed by ICP in the filtrate of the original sample, mg/l

  • EFFECT OF REGRINDING CONDITIONS ON THE

    Pyrite recovery after primary grinding, and after regrinding with different grinding media. Water recovery with different dosages of CuSO 4 •5H 2 O addition during regrinding, collector=640 g/t ...

  • A study on the effect of active pyrite on flotation of ...

    2018-6-27  depressing pyrite. 5 The effect of the grinding media conditions were investigated (Peng and Grano, 2010). The grinding media 2010 The grinding media led to a decrease in the amount of floating pyrite. 6 The effects of the amount of pyrite on the chalcopyrite recovery with X-ray photoelectron spectroscopy (XPS) were considered (Owusu et al., 2011).

  • China Ceria Zirconia Beads for Pyrite - China Ceria ...

    China Ceria Zirconia Beads for Pyrite, Find details about China Ceria Zirconia Grinding Media, Cerium Zirconia Balls from Ceria Zirconia Beads for Pyrite - ZIBO QIMINGXING NEW MATERIAL INCORPORATED CO., LTD.

  • Effect of grinding media on the activation of pyrite

    The effect of grinding media on the flotation of pyrite activated by Cu(2+) or Pb(2+) is through the change of pulp potential and iron oxidation species emanating from the media. The iron oxidation species from grinding media is electrostatically repulsive with respect to copper-activated pyrite and therefore, reducing conditions produced by ...

  • Effect of pyrite and pyrrhotite on the corrosive wear of ...

    The electrochemical behavior of a three-electrode system involving pyrrhotite, pyrite, and grinding media was also investigated as a first step toward elucidating the nature of interactions that occur in grinding complex sulfide ores. SME preprint 87-11, SME-AIME Annual Meeting, Denver, CO, February 1987. MMP paper 87-604.

  • The interaction of grinding media and collector in pyrite ...

    The interaction of grinding media and collector in pyrite flotation at alkaline pH Highlights•Pyrite recovery with forged steel was higher than that with chrome steel at pH 8.5.•An increase in PAX dosage did not improve pyrite recovery with chrome steel.•At pH 8.5 ...

  • An investigation into the effects of pulp chemistry

    Pyrite is reactive and can easily oxidise when exposed to air or oxygen. Pyrite and most sulphide minerals are more inert than the electrochemically reactive grinding media. Therefore, during grinding, grinding media come into frequent contact with sulphide minerals and a galvanic couple is created between the grinding media and sulphides.

  • 10.1016/j.mineng.2005.06.005 DeepDyve

    Nomenclature α Py/MS surface area ratio of pyrite to mild steel α surface area rate of pyrite contacting with mild steel A MS and A Py surface area of mild steel and pyrite respectively, cm 2 A Py ( t ) surface area of pyrite and a function of the grinding time, cm 2 [ C aq ] concentration of the metal ion or sulphur analysed by ICP in the ...

  • Effect of Grinding Media on Flotation Chemistry

    2020-7-22  To investigate the electrochemical characteristics of grinding media materials and minerals used in this study, electrodes of pyrrhotite, pyrite and mild steel were prepared by mounting the samples in lucite tubing of 0.625 cm I.D. with a 3M Scotch-Weld structural adhesive, so that about 0.16 cm² of their surfaces were exposed to the solution.

  • The effect of pH, solid content, water chemistry and ore ...

    2013-12-5  Abstract: The role of pH, solid content, water chemistry and ore mineralogy on the galvanic interactions between chalcopyrite and pyrite and low alloy steel balls were investigated in the grinding of Sarcheshmeh porphyry copper sulfide ore.

  • Electrochemical properties of pyrite, pyrrhotite, and ...

    2012-10-26  pyrite and pyrrhotite from other sulphide minerals. Understanding of activation and depression of sulphide minerals, such as pyrite and pyrrhotite, as well as grinding media such as steel balls, under both acidic and alkaline conditions, is necessary to improve recovery and to design process strategies for cost reduction. These parameters can ...

  • Improving The Efficiency Of Fine Grinding –

    2017-12-21  coefficient as a new tool in characterising stirred milling grinding media. The first application of this ceramic media will be regrinding a gold bearing, pyrite rich sulphide flotation concentrate in the industry’s largest stirred mill; the M10,000 IsaMill. 1 INTRODUCTION The high

  • The Adsorption of Cu Species onto Pyrite Surface and

    The adsorption of Cu species onto pyrite surface and its effect on flotation were investigated by using microflotation tests, first-principle calculations, and XPS surface analysis. The results indicated that the flotation of pyrite appears to be activated with CuSO 4 only at alkaline pH, while being depressed at acidic and neutral pH.

  • The interaction between grinding media and collector

    2020-5-11  Gold often coexists with pyrite as micron and submicron-inclusions and pyrite is therefore floated to maximize gold recovery in gold processing plants. In practice, different types of grinding media and a great range of pH and collector concentrations are used for pyrite flotation without scientific guidance. In this study, the effect of three different types of grinding media including forged ...

  • The interaction of grinding media and collector in pyrite ...

    The interaction of grinding media and collector in pyrite flotation at alkaline pH Highlights•Pyrite recovery with forged steel was higher than that with chrome steel at pH 8.5.•An increase in PAX dosage did not improve pyrite recovery with chrome steel.•At pH 8.5 ...

  • Galvanic Interaction between Chalcopyrite and Pyrite

    Pyrite and chalcopyrite, the most common and exploitable sulphide minerals, usually occur together and in contact with each other. Therefore, this paper was aimed to investigate the effect of galvanic interaction among chalcopyrite and pyrite with grinding media in grinding the Sarcheshmeh copper ore.

  • Interaction of copper(II) ions with pyrite and its ...

    Simultaneously, the amount of adsorbed Cu(I) increases until the same Cu(I) level is reached as in acidic media. After subsequent immersion in ethyl xanthate solution of pH 6–9, both Cu(I) and Cu(II) ions adsorbed on pyrite are found to form Cu(I) ethyl xanthate in accordance with previously published infrared spectroscopic and microflotation ...

  • Surface Behavior of Iron Sulfide Ore during Grinding

    This research was conducted to study the oxidation and surface modification of pyrite in an inert mill and alumina grinding media at different pH values. The extent and progress of the oxidation function of milling time, by measuring some physicochemical variables, zeta

  • grinding media pyrite - benb-bennekom.nl

    Oct 01, 2005 Galvanic interaction of grinding media with pyrite and its effect on floatation Galvanic interaction of grinding media with pyrite and its effect on floatation Huang, G.; Grano, S. 2005-10-01 00:00:00 A specialized grinding system linked to an electrochemical analysis set was used to quantify galvanic interactions between mild steel and pyrite.

  • Effect of Grinding Media on Flotation Chemistry

    2020-7-22  To investigate the electrochemical characteristics of grinding media materials and minerals used in this study, electrodes of pyrrhotite, pyrite and mild steel were prepared by mounting the samples in lucite tubing of 0.625 cm I.D. with a 3M Scotch-Weld structural adhesive, so that about 0.16 cm² of their surfaces were exposed to the solution.

  • Improving The Efficiency Of Fine Grinding –

    2017-12-21  coefficient as a new tool in characterising stirred milling grinding media. The first application of this ceramic media will be regrinding a gold bearing, pyrite rich sulphide flotation concentrate in the industry’s largest stirred mill; the M10,000 IsaMill. 1 INTRODUCTION The high

  • Fine Grinding as Enabling Technology – The IsaMill

    2017-12-21  The use of steel media, however, can still be detrimental to a leaching process. When fine grinding pyritic concentrates of precious metals, it is common to follow the fine grinding stage with a pre-aeration stage to remove active pyrite and pyrrhotite before cyanidation. Worn steel media in the ground pyrite can significantly

  • The interaction of grinding media and collector in

    2020-5-11  A significant proportion of invisible gold is hosted by pyrite and the successful recovery of this gold requires a high recovery of pyrite in flotation. In the industry, the flotation of gold-bearing pyrite is operated in a broad range of pH and collector concentration with different types of grinding media. Following the previous study at pH 5.0 and 7.0, the current study investigated the ...

  • pyrite grinding flow - studi-internazionali.it

    During wet grinding, water allows the flow of electrons within the pulp (galvanic interactions between minerals themselves and minerals and grinding media). Pyrite is reactive and can easily oxidise when exposed to air or oxygen. Pyrite and most sulphide minerals are more inert than the electrochemically reactive grinding media.

  • grinding media pyrite - benb-bennekom.nl

    Oct 01, 2005 Galvanic interaction of grinding media with pyrite and its effect on floatation Galvanic interaction of grinding media with pyrite and its effect on floatation Huang, G.; Grano, S. 2005-10-01 00:00:00 A specialized grinding system linked to an electrochemical analysis set was used to quantify galvanic interactions between mild steel and pyrite.

  • Fine grinding—Developments in ceramic media

    2019-1-26  media has given significant benefits to the users of IsaMills. Grinding media types Until 2005, all IsaMill installations have taken advantage of the technology’s ability to use low cost, but relatively low quality grinding media such as silica sand, river pebble, smelter slag or fine primary mill scats (autogenous milling).

  • An Electrochemical Study of Pyrrhotite-Grinding

    2019-9-22  (1987) Effect of pyrite and pyrrhotite on the corrosive wear of grinding media. Mining, Metallurgy Exploration 4 :3, 166-171. Online publication date: 1-Aug-1987.

  • Studies of Grinding Media Corrosion from Galvanic ...

    This study has been done to determine the galvanic interaction between five types of grinding media (mild steel, cast iron, 10% chromium, 20% chromium, and ceramic media) and galena, in situ of the mill. The ceramic media has a significantly not galvanic interaction with galena and high chromium media has a significantly weaker galvanic interaction with galena, and produces a very much lower ...

  • Fine Grinding as Enabling Technology – The IsaMill

    2017-12-21  The use of steel media, however, can still be detrimental to a leaching process. When fine grinding pyritic concentrates of precious metals, it is common to follow the fine grinding stage with a pre-aeration stage to remove active pyrite and pyrrhotite before cyanidation. Worn steel media in the ground pyrite can significantly

  • Effect of Regrinding Conditions on the Flotation of ...

    The mild steel grinding media had a detrimental effect on both chalcopyrite and pyrite flotation. This study addresses the importance of choosing suitable regrinding conditions in the pyrite and copper flotation circuit. CITATION: Chen, X, Peng, Y and Bradshaw, D J, 2012. Effect

  • Pyrite Manufacturers Suppliers, China pyrite ...

    pyrite manufacturer/supplier, China pyrite manufacturer factory list, find qualified Chinese pyrite manufacturers, suppliers, factories, exporters wholesalers quickly on Made-in-China.

  • 尹周澜 - 中南大学 - 化学化工学院 - X-MOL

    Light Metals, 2007, 157-161 Ding Zhiying, Yin Zhoulan, Liu Lu, et al. Effect of grinding parameters on the rheology of pyrite-heptane slurry in a laboratory stirred media mill. Minerals Engineering, 2007, 20(7): 701-709 Yin Zhoulan, Zhong Shengkui, Wang Zhixing, et al. Synthesis and Electrochemical Properties of the Cathode Material Li_3V_2(PO_4)_3.